物質安全資料表(參考格式)
一、物品與廠商資料/Product and Company Identification
物品名稱:合金铝材 A5052 Product Name |
產品編號:N/A Product Code |
建議用途及限制使用: Suggestion and Restriction on application: |
製造商或供應商名稱、地址及電話: 尼尔金属(苏州)有限公司 Address & Tel. of Manufacturer or Agent:苏州市吴中区郭巷镇尹山路68号 TEL:0512-6596 9698 |
緊急聯絡電話/傳真電話:TEL:0512-6596 9698 FAX: 0512-6596 8886 Emergency Phone Number/Fax |
二、危害辨識資料/ Hazard Identification
物品危害分類/Hazard Classification: |
GHS標示內容 / GHS Label Elements 存放時注意不要和强酸,強氧化劑放在一起 象徵符號 Symbol:不適用 警示語/Singal Words:不適用 危害警告訊息/Hazard statement:不適用 危害防範措施/Precaution:不適用 |
其它危害 Others:不適用 |
三、成分辨識資料/Composition, Information on Ingredients
純物質/Pure Material﹕
中英文名稱Material name﹕铝Al 镁Mg |
同義名詞Synonyms﹕無 |
化學文摘社登記號碼(CAS N0﹒)﹕铝Al 7429-90-5 镁Mg 7439-95-4 |
危害物質成分(成分百分比) Hazard Ingredients Composition﹕ |
混合物質/Mixture:
危害物質成分之中英文名稱 Names of Hazardous Chemicals | 濃度及濃度範圍(成分百分比) Consistency & tolerance | 化學文摘社登記號碼 (CAS N0﹒)﹕ |
硅Si, 铁Fe, 铜Cu, 錳Mn | 0.25%,0.4%,0.1%,0.1%, | 铝Al 7429-90-5 |
镁Mg, 铬Cr, 锌Zn 铝Al | 2.2-2.5%,0.15-0.35%,0.1%,REM | 镁Mg 7439-95-4 |
四、急救措施/ First Aid Measures
不同暴露途徑之急救方法/ First Aid Measures for Different Kinds of Exposures: ˙吸入/Inhalation:脱离现场至空气新鲜处,呼吸困难给输氧,就医 ˙皮膚接觸/Skin Contact:用肥皂水和清水彻底冲洗皮肤 ˙眼睛接觸/Eye Contact:用大量流动清水或生理盐水彻底冲洗15分钟 ˙食入/Ingestion:催吐 就医 |
最重要症狀及危害效應/Most Important Symptoms and Hazard Reactions:接触高浓度镍出现肺水肿和呼吸道衰竭,六价铬中毒以局部损害发展到不可就医 |
對急救人員之防護/Protection to First-Aid Attendants: 戴自吸式过滤防尘口罩 |
對醫師之提示/Suggestions to Doctors:目前查無相關資料 |
五、滅火措施/ Fire Fighting Measures
適用滅火劑/Suitable Extinguishing Media:干粉,砂土 |
滅火時可能遭遇之特殊危害/Special Hazards in Fire:爆炸,中毒 |
特殊滅火程序/Special Fire-Fighting Procedures:在上风处灭火 |
消防人員之特殊防護設備/Required Special Protective Equipment for Fire-Fighters:戴自吸式过滤防尘口罩,穿全身防火防毒服
|
六、洩漏處理方法/ Accidental Release Measures
個人應注意事項/ Personal Precautions:戴自吸式过滤防尘口罩, 穿防毒服 |
環境注意事項/Environmental Precautions:隔离泄露污染区,限制出入,切断火源,使用无火花工具收集于干燥洁净的有盖容器中 |
清理方法/Methods for Cleaning:镍污染可以使用是会中和,六价铬废水常用方法是硫酸亚铁—石灰法,离子交换法 |
七、安全處置與儲存方法/ Handling and Storage
處置/Handling:隔离,收集回收 |
儲存/ Storage:密闭的容器 |
八、暴露預防措施/ Exposure Controls, Personal Protection
工程控制/ Engineering Measures: |
控制參數/ Control Parameters: ˙八小時日時量平均容許濃度(TWA)/短時間時量平均容許濃度(STEL)/最高容許濃度(CEILING): ˙生物指標/ BEIs:目前查無相關資料 |
個人防護設備/ Personal Protection Equipment: ˙呼吸防護/Respiration:防尘口罩 ˙手部防護/Hand:穿防毒服 ˙眼睛防護/Eye:面罩 ˙皮膚及身體防護/Skin & Body:穿防毒服 |
衛生措施/Hygiene Measures:目前查無相關資料 |
九、物理及化學性質/ Physical and Chemical Properties
物質狀態/ State of Substance:镍是银白色坚硬金属,铬钢灰色,质脆而硬 | 形狀/Appearance:固态 |
顏色/Color:银白色 | 氣味/Odor:无 |
pH值/pH Value:N/A | 沸點/沸點範圍/Boiling Point:铝 660℃,镁 649℃ |
熔點/凝固點 Melting /Solidify Point:無 | 揮發速率/Evaporative Speed:無 |
分解溫度/Decomposing Temperature: 查無相關資料 | 閃火點: ℉ ℃ Flashpoint 測試方法: 開杯 閉杯 Test Methods:Open Slot Closed Slot |
自燃溫度/Self-Igniting Temperature:查無相關資料 | 爆炸界限/Explosion Limits:N/A |
蒸氣壓/Vapor Pressure:查無相關資料 | 蒸氣密度/Vapor Density:N/A |
密度/Density:铝2.70 镁 1.74 | 溶解度/Dissolution:不溶于水 |
分配係數/Distribution factor:無 | |
十、安定性及反應性/Stability and Reactivity
安定性/Stability: 安全穩定 |
特殊狀況下可能之危害反應/Possible Hazard Reaction Under Special Conditions: 查無相關資料 |
應避免之狀況/Conditions to Avoid: 查無相關資料 |
應避免之物質/Materials to Avoid: 强酸強氧化劑 |
危害分解物/Hazardous Decomposition Products: 查無相關資料 |
十一、毒性資料/ Toxicological Information
急毒性/Acute Toxicity:铝没有急毒性,镁无有害作用 |
局部效應/Local Reactions:查無相關資料 |
致敏感性/Sensitivity:查無相關資料 |
慢毒性或長期毒性/Chronic or Long Term Toxicity:查無相關資料 |
特殊效應/Special Reactions:查無相關資料 |
十二、生態資料/ Ecological information
可能之環境影響/環境流佈/Possible Environmental Impact/Environmental Run-offs: 查無相關資料 |
十三、廢棄處置方法/Disposal considerations
廢棄處置方法/Disposal Methods:隔离回收 |
十四、運送資料/Transport information
國際運送規定/International Transportation Regulations: 查無相關資料 |
聯合國編號/UN Reference No.:查無相關資料 |
國內運送規定/Domestic Transportation Regulations:查無相關資料 |
特殊運送方法及注意事項/Special Transportation Methods and Precautions: 查無相關資料 |
十五、法規資料/Regulatory information
適用法規/Applicable Regulation: 中国(TJ36-79) 中国(GB16297-1996) |
十六、其他資料/Other information
參考文獻 Ref. Document | CHEMNFO資料庫,98-2,HSDB資料庫,TOMES等 | |
製表單位 Department | 名稱/Dept. Name:尼尔金属(苏州)有限公司 | |
地址/電話Address/Tel.:0512-6596 9698 | ||
製 表 人 Made By | 職稱/Title:资材 | 姓名: 尤勇 Name |
製表日期 Date Prepared | 2010/10/13 | |